Journal of Advanced Pharmaceutical Technology & Research

ORIGINAL ARTICLE
Year
: 2020  |  Volume : 11  |  Issue : 2  |  Page : 53--58

Formulation of anti-acne concealer containing cinnamon oil with antimicrobial activity against Propionibacterium acnes


Jinmica Veerasophon1, Pattana Sripalakit2, Aurasorn Saraphanchotiwitthaya3,  
1 Department of Pharmaceutical Technology, Chemistry and Pharmacognosy, Faculty of Pharmaceutical Sciences, Naresuan University, Phitsanulok 65000, Thailand
2 Pharmaceutical Biotechnology Research Unit; Pharmaceutical Chemistry and Pharmacognosy, Faculty of Pharmaceutical Sciences, Naresuan University, Phitsanulok 65000, Thailand
3 Department of Pharmaceutical Technology; Pharmaceutical Biotechnology Research Unit, Faculty of Pharmaceutical Sciences, Naresuan University, Phitsanulok 65000, Thailand

Correspondence Address:
Dr. Aurasorn Saraphanchotiwitthaya
Department of Pharmaceutical Technology, Faculty of Pharmaceutical Sciences, Naresuan University, Phitsanulok 65000
Thailand

Abstract

This study aimed to develop an anti-acne concealer containing essential oil with anti-Propionibacterium acnes activity. Antimicrobial activity of cinnamon oil, galangal oil, and eucalyptus oil against P. acnes DMST 14916 was assayed using agar disc diffusion and the broth dilution method. Cinnamon oil showed the maximum inhibitory activity against P. acnes with a clear zone diameter of 36.75 ± 1.06 mm, compared to 14.67 ± 0.58 and 41.83 ± 1.04 mm for tea tree oil and clindamycin, respectively. The minimum inhibitory concentration value of cinnamon oil was 5 mg/mL. Among five formulations of concealer incorporating 0.5% w/w cinnamon oil, F4 provided good texture, coverage, and spreadability with anti-P. acnes activity and stable under determined storage conditions. Cinnamon oil could be a promising cosmetic ingredient for anti-acne products, and F4 concealer may be useful for both covering skin imperfections and the management of acne.



How to cite this article:
Veerasophon J, Sripalakit P, Saraphanchotiwitthaya A. Formulation of anti-acne concealer containing cinnamon oil with antimicrobial activity against Propionibacterium acnes.J Adv Pharm Technol Res 2020;11:53-58


How to cite this URL:
Veerasophon J, Sripalakit P, Saraphanchotiwitthaya A. Formulation of anti-acne concealer containing cinnamon oil with antimicrobial activity against Propionibacterium acnes. J Adv Pharm Technol Res [serial online] 2020 [cited 2021 Sep 19 ];11:53-58
Available from: https://www.japtr.org/text.asp?2020/11/2/53/283068


Full Text



 Introduction



Acne is a common dermatological disease that mainly affects adolescents. It can lead to both physical and psychological effects, resulting in depression, poor self-esteem, and suicidal tendencies.[1] Acne vulgaris is diagnosed by the presence of various clinical manifestations such as closed and open comedones, papules, pustules, cysts, and nodules.[2] The underlying pathogenesis of these lesions is multifactorial and includes high sebum secretion, hyperkeratinization, hormonal changes, and bacterial infection.[3]Propionibacterium acnes plays a significant role in the pathogenesis of acne. This bacterium can activate certain inflammatory mediators and metabolize sebaceous triglycerides into fatty acids, which induce the attraction of white blood cells to the plugged follicle, leading to skin inflammation. When the wall of the hair follicle is broken down, sebum, dead cells, and bacteria are secreted leading to a spectrum of acne severity.[4] Current treatments of acne include topical therapies (comedolytic agents, antibiotics, and anti-inflammatory drugs) and systemic therapies (antibiotics, zinc, and hormones).[5],[6] However, these drugs cause various potential side effects, and long-term treatment with antibiotics may lead to the antibiotic resistance among acne-causing bacteria.[5]

The study was to evaluate the antimicrobial activity of cinnamon oil, galangal oil, and eucalyptus oil against P. acnes, compared to tea tree oil and clindamycin. The most effective volatile oil was incorporated into a silicone-based concealer, and the best formulation was examined for physical, chemical, and microbial stabilities.

 Materials and Methods



Chemicals

P. acnes DMST 14916 were purchased from the National Institutes of Health, Thailand. The study was approved by the Institutional Biosafety Committee, Naresuan University, Thailand. The ingredients of the formulation were purchased from Namsiang Trading Co., Ltd., Thailand. Essential oils, kojic dipalmitate, and dimethicone were purchased from Chemipan Corporation Co., Ltd., Thailand. Clindamycin was obtained from Pfizer international Co., Ltd. Brain–heart infusion (BHI) agar and BHI broth were purchased from Merck, Germany.

Culture methods

P. acnes DMST 14916 was stored on BHI agar in an anaerobic jar at 37°C for 48 h. A suspension of P. acnes in BHI broth was prepared. The inoculated broths were adjusted to 0.5 McFarland standard turbidity with an approximate optical density (OD) of 0.08–0.13 at 600 nm.

Agar disc diffusion assay

Three hundred microliters of P. acnes suspension (1.5 × 108 CFU/mL) was spread on BHI agar. Paper discs (6.0 mm diameter) were impregnated with 20 μL of the tested samples, subsequently being placed and gently pressed on BHI agar. Clindamycin (1% w/v) was used as a positive control, whereas distilled water was used as a negative control. The inoculated plates were incubated at 37°C for 48 h under the anaerobic system. After incubation, the clear zone diameter was measured by Vernier Caliper.[7] To determine the antimicrobial activity of the concealer against P. acnes, concealer (0.5 g) was applied to the agar well instead of the paper disc.

Broth dilution method

Various concentrations (0.25%, 0.5%, 1.0%, and 2.0% w/v) of essential oils were prepared by 2% w/v dimethylsulfoxide (DMSO) and 2% w/v Tween-80 as a solubilizing agent, diluted with BHI broth. Three hundred microliters of P. acnes suspension (1.5 × 108 CFU/mL) was mixed with 2 mL of tested oils. Liquid paraffin was added and each tube was sealed tightly with Parafilm before being incubated at 37°C for 48 h in the anaerobic jar. The minimum inhibitory concentration (MIC) values were obtained from the lowest concentration of tested samples that inhibited bacterial growth in which the clear mixture was observed.[7] Clindamycin (1% w/v) was used as a positive control, whereas BHI broth containing solubilizing agent was used as a negative control. The result was confirmed by determination of OD values of the tested mixture using a microplate reader at 600 nm. The OD value was read promptly after mixing and 48 h postincubation. The percentage of growth inhibition was calculated as follows:

[INLINE:1]

where sample: oil in BHI broth with P. acnes, blank: oil in BHI broth, and control: BHI broth with P. acnes. The MIC50 and MIC90 values were defined as the minimum concentration necessary to achieve ≥50% and ≥90% inhibition of growth, respectively.

Gas chromatography–mass spectrometry analysis

The chemical analysis was done by gas chromatography (GC) (Hewlett Packard, Hewlett Manufacturing Co., USA) equipped with a HP-5MS column (30 m × 0.25 mm × 0.25 mm). The oven temperature was programmed as isothermal at 40°C for 1 min, then raised to 250°C at a rate of 6°C/min, and held at this temperature for 4 min. Helium was used as a carrier gas at the rate of 1.0 mL/min. The scan range was 40–500 amu.[8] Cinnamaldehyde was designated as a marker in cinnamon oil and identified by comparing the retention indices of the peaks at 13.4 min. To evaluate the cinnamaldehyde content in the formulation, a mixture of 0.5 g concealer and 5 mL hexane was shaken thoroughly before being sonicated for 15 min and filtered through a 0.45-micron filter. The filtrate was collected for GC-mass spectrometry (MS) analysis.

Formulation of concealer

We expected to formulate a stable water-in-silicone emulsion concealer, providing a viscous texture, good coverage, and spreadability with anti-P. acnes activity for yellow skin tones. Five formulations of concealer, labeled as F1-F5, containing 0.5% w/w cinnamon oil were prepared. The content of dimethicone, wax, pigments, and distilled water was optimized. Titanium dioxide and pigments were uniformly blended and then mixed with the mixture of various dimethicone. Kojic dipalmitate was dissolved in mineral oil, and waxes were then mixed with the dimethicone mixture before heating to 70°C. Magnesium aluminum silicate and propylene glycol were mixed in water and heated to 75°C. Silicone-based concealer was prepared by the addition of the aqueous phase to the lipophilic phase and stirred continuously. Emulsification was achieved by homogenization at 3500 rpms and volatile oil was added after the preparation had cooled down. The formulation which met our specific requirements was selected for stability testing.

Stability testing

The formulation was kept at room temperature (25°C ± 2°C) for 30 days or under heating/cooling cycle between 4°C and 45°C for 6 cycles. At the end of the storage time, the physical changes, including color, odor, separation, spreadability, and coverage properties, were determined by visual observation, and viscosity was measured using a rheometer (Brookfield® Model DV-III, Brookfield AMETEK, USA). The pH was determined using a pH meter, and cinnamaldehyde content was evaluated using GC-MS. Microbial contamination was performed using the streak plate technique.

Data analysis

All experiments were repeated three times. The results were represented as mean ± standard deviation and were analyzed using one-way analysis of variance with the threshold for statistical significance set at the level of P < 0.05.

 Results and Discussion



Antimicrobial activity of various volatile oils against Propionibacterium acnes

Various herbs and naturally derived compounds have been reported to exhibit anti-acne activity.[6] Tea tree oil is widely used in acne care products. It is effective against various strains of P. acnes and has anti-inflammatory activity.[9] Terpinen-4-ol has been reported to be its main component responsible for these activities.[10] Cinnamon has been used for the treatment of various diseases such as diabetes, inflammation, and acne.[11] The constituents of cinnamon oil from Cinnamomum zeylanicum bark are mainly composed of cinnamaldehyde and eugenol.[12] Lesser galangal oil is obtained from the rhizome of Boesenbergia pandurata (Roxb.) Schltr. which has been reported for anti-inflammatory, antitumor, and antidiarrheal activities.[13] The major compounds of galangal oil composed of g-terpinene, geraniol, camphor, b-ocimene, 1,8-cineole, myrcene, and borneol.[14] Eucalyptus oil is obtained from the fresh leaves of Eucalyptus globulus, and 1,8-cineole has been reported to be an active ingredient.[15] It has been shown to possess antibacterial, anti-inflammatory activity[16] and facilitating wound healing.[4]

As seen in [Table 1] and [Figure 1], all tested oils showed the formation of clear zones which was more than that from tea tree oil but significantly less than clindamycin solution, indicating their antibacterial activity that was capable of inhibiting or slowing the growth of P. acnes. The maximum inhibition zone was observed with cinnamon oil, followed by galangal oil and eucalyptus oil, respectively. Antimicrobial activity of the combinations of the two most effective essential oils was assayed. Mixing a high ratio (by weight) of galangal oil and cinnamon oil led to a reduction of the clear zone. Therefore, cinnamon oil was selected for further study.{Table 1}{Figure 1}

As shown in [Table 2], the lowest concentration of cinnamon oil that was associated with the absence of visually observed microbial growth was 0.5% w/v. The MIC50 and MIC90 values of cinnamon oil were 0.25% w/v and 1.0% w/v, respectively. Based on these findings, 0.5% w/w cinnamon oil was incorporated in the formulation. These results were in accordance with many previous studies indicating that cinnamon oil was a potent antimicrobial agent against various microbial strains including Staphylococcus epidermidis, P. acnes,[5] and multidrug-resistant strains of Pseudomonas aeruginosa.[11]{Table 2}

GC-MS analysis

GC-MS analysis of cinnamon oil is presented in [Figure 2]. The major compounds were cinnamaldehyde (29.0%, 13.40 min), benzyl benzoate (19.9%, 23.42 min), and linalool (11.9%, 9.38 min). Previous research had found cinnamon bark oil to be rich in trans-cinnamaldehyde, with antimicrobial effects;[17] the acrolein group in the molecules was shown to be essential for these beneficial effects.[18] The antibacterial mechanisms of cinnamon oil have been discussed previously.[19]{Figure 2}

Formulation of concealer

Cyclopentasiloxane (and) PEG/PPG-18/18 dimethicone was used as an emulsifier, silicone wax C30-45 alkyl dimethicone was used as a thickening agent, candelilla wax and beeswax were used as stiffening agents, and the silicon-based polymer dimethicone was used to improve skin smoothness. A list of ingredients in F1–F5 formula and the physical appearance of their finished products are shown in [Table 3]. Among the five formulations, F4 met our specific requirements and was selected for stability testing. The freshly prepared F4 was water in silico ne oil emulsion with fairly high viscosity and a slightly acidic pH. The color was the lightest yellowish-brown, with mild and pleasant odor of light cinnamon. The product gave a good texture without separation, providing good coverage and spreadability.{Table 3}

Stability testing

After storage at room temperature for 1 month or 6 cycles of the heating/cooling cycle, F4 still had a good texture, without phase separation. The viscosity, color, scent, and pH did not change, and microbial growth was not observed. The percentage of remaining cinnamaldehyde in F4 was over 90%. These findings indicate that F4 was physically, chemically, and microbially stable under storage conditions and may remain stable throughout the intended shelf-life period. Evaluation of the stability of F4 concealer is shown in [Table 4].{Table 4}

F4 showed anti-P. acnes activity with the inhibition zones of 18.00 ± 1.41 mm. This was less than that observed from the pure cinnamon oil, which may be due to the restricted spreadability of cinnamon oil through a viscous product. Base formulations showed no inhibitory effect. Anti-P. acnes activity of F4 stored under room temperature and accelerated conditions was not significantly different, with inhibition zones of 17.25 ± 1.06 mm and 16.75 ± 0.35 mm, respectively. However, instability of trans-cinnamaldehyde after air exposure has been reported, with reactive unsaturated aldehyde being readily oxidized to cinnamic acid before volatile loss;[20] to avoid instability due to oxidation reactions during its use, encapsulation technique and effective antioxidants might be applied.

 Conclusions



Cinnamon oil, galangal oil, eucalyptus oil, and combinations of galangal and cinnamon oil exhibited different extents of anti-P. acnes activity. Among all the tested oils, the most effective compound was cinnamon bark oil. It contains cinnamaldehyde as a major constituent, which might be responsible for the anti-P. acnes activity. Cinnamon oil might be a promising cosmetic ingredient for anti-acne products. F4, a silicone-based emulsion concealer containing 0.5% w/w cinnamon oil, exhibited physical, chemical, and microbial stabilities after storage in multiple predetermined conditions. F4 concealer could be used to help cover skin imperfections with anti-acne activity. However, further investigation in clinical research is required.

Financial support and sponsorship

This study was financially supported by the National Research Council of Thailand through Naresuan University, grant number R2562B003.

Conflicts of interest

There are no conflicts of interest.

References

1Halvorsen JA, Stern RS, Dalgard F, Thoresen M, Bjertness E, Lien L. Suicidal ideation, mental health problems, and social impairment are increased in adolescents with acne: A population-based study. J Invest Dermatol 2011;131:363-70.
2Layton AM. Disorders of the sebaceous glands. In: Burns T, Breathnach S, Cox N, Griffiths C, editors. Rook's Textbook of Dermatology. 8th ed. New Jersey: Wiley-Blackwell; 2010. p. 42.1.1.
3Fried R, Friedman A. Psychosocial sequelae related to acne: Looking beyond the physical. J Drugs Dermatol 2010;9:s50-2.
4Kapoor S, Saraf S. Topical herbal therapies an alternative and complementary choice to combat acne. Res J Med Plant 2011;5:650-69.
5Daud FS, Wankhede S, Joshi M, Pande G. Development of herbal anti acne gel and its evaluation against acne causing bacteria Propionibacterium acnes and Staphylococcus epidermidis. Int J Res Ayurveda Pharm 2013;4:781-6.
6Zaenglein AL, Pathy AL, Schlosser BJ, Alikhan A, Baldwin HE, Berson DS, et al. Guidelines of care for the management of acne vulgaris. J Am Acad Dermatol 2016;74:945-7.e33.
7Viyoch J, Pisutthanan N, Faikreua A, Nupangta K, Wangtorpol K, Ngokkuen J. Evaluation of in vitro antimicrobial activity of Thai basil oils and their micro-emulsion formulas against Propionibacterium acnes. Int J Cosmet Sci 2006;28:125-33.
8Pooja A, Arun N, Maninder K. GC-MS profile of volatile oils of Cinnamomum zeylanicum Blume and Ocimum kilimandscharicum baker ex gurke. Int J Pharm Sci Rev Res 2013;19:124-6.
9Brand C, Grimbaldeston MA, Gamble JR, Drew J, Finlay-Jones JJ, Hart PH. Tea tree oil reduces the swelling associated with the efferent phase of a contact hypersensitivity response. Inflamm Res 2002;51:236-44.
10Hart PH, Brand C, Carson CF, Riley TV, Prager RH, Finlay-Jones JJ. Terpinen-4-ol, the main component of the essential oil of Melaleuca alternifolia (tea tree oil), suppresses inflammatory mediator production by activated human monocytes. Inflamm Res 2000;49:619-26.
11Nabavi SF, Di Lorenzo A, Izadi M, Sobarzo-Sánchez E, Daglia M, Nabavi SM. Antibacterial effects of cinnamon: From farm to food, cosmetic and pharmaceutical industries. Nutrients 2015;7:7729-48.
12Utchariyakiat I, Surassmo S, Jaturanpinyo M, Khuntayaporn P, Chomnawang MT. Efficacy of cinnamon bark oil and cinnamaldehyde on anti-multidrug resistant Pseudomonas aeruginosa and the synergistic effects in combination with other antimicrobial agents. BMC Complement Altern Med 2016;16:158.
13Song MS, Shim JS, Gwon SH, Lee CW, Kim HS, Hwang JK. Antibacterial activity of panduratin A and isopanduratin A isolated from Kaempferia pandurata roxb. against acne-causing microorganisms. Food Sci Biotechnol 2008;17:1357-60.
14Chahyadi A, Hartati R, Wirasutisna KR, Elfahmi. Boesenbergia pandurata Roxb., an Indonesian medicinal plant: Phytochemistry, biological activity, plant biotechnology. Procedia Chem 2014;13:13-57.
15Giamakis A, Kretsi O, Chinou I, Spyropoulos CG. Eucalyptus camaldulensis: Volatiles from immature flowers and high production of 1,8-cineole and beta-pinene by in vitro cultures. Phytochemistry 2001;58:351-5.
16Murata S, Shiragami R, Kosugi C, Tezuka T, Yamazaki M, Hirano A, et al. Antitumor effect of 1, 8-cineole against colon cancer. Oncol Rep 2013;30:2647-52.
17Schmidt E, Jirovetz L, Buchbauer G, Eller GA, Stoilova I, Krastanov A, et al. Composition and antioxidant activities of the essential oil of cinnamon (Cinnamomum zeylanicum blume) leaves from Sri Lanka. J Essent Oil Bear Pl 2006;9:170-82.
18Bae KH, Ji JM, Park KL. The antibacterial component from Cinnamomi cortex against a cariogenic bacterium Streptococcus mutans OMZ 176. Arch Pharm Res 1992;15:239-41.
19Vasconcelos NG, Croda J, Simionatto S. Antibacterial mechanisms of cinnamon and its constituents: A review. Microb Pathog 2018;120:198-203.
20Smith CK, Moore CA, Elahi EN, Smart AT, Hotchkiss SA. Human skin absorption and metabolism of the contact allergens, cinnamic aldehyde, and cinnamic alcohol. Toxicol Appl Pharmacol 2000;168:189-99.